does a fire tube boiler have wet back

Product thermal capacity: 4-35 t/h
Working pressure: 1.0-2.5 MPA
Outlet temperature:: 184-350 ℃
Available fuel: Bituminous coal, lean coal, anthracite
Available industries: Heating, chemical, food, tobacco, textile, print and dyeing, feed, medicine, building materials, wine, hospital

Boiler room Guide - cleaverbroo

2018-8-5 · hot gases to transfer its heat through the tube wall into the water. The boiler water flows by convection from the lower drum to the upper drum. arrangements have been developed to maximize boiler efficiency and pressure Furnaces can be located high or low within the boiler shell. Boilers are available as dry back or wet back (water

Get A Quote

Scotch marine boiler - Wikiped

2019-5-10 · A "Scotch" marine boiler (or simply Scotch boiler) is a design of steam boiler best known for its use on ships. Sectional diagram of a "wet back" boiler The general layout is that of a squat horizontal cylinder. One or more large cylindrical furnaces are in the lower part of the boiler shell. Above this is a large number of small-diameter fire

Get A Quote

Fire-tube boiler - Wikiped

2019-5-13 · Fire-tube boilers sometimes have water-tubes as well, to increase the heating surface. A Cornish boiler may have several water-tubes across the diameter of the flue (this is common in steam launches). A locomotive boiler with a wide firebox may have arch tubes or thermic syphons.

Get A Quote

WETBACK DESIGN vs HARD REFRACTORY DRYBACK

2012-2-20 · WETBACK DESIGN vs HARD REFRACTORY DRYBACK DESIGN WHY IS A WETBACK DESIGN BETTER? As indicated in the drawing, a three-pass wetback design has a rear water wall, which separates the primary heating surface of the combustion chamber from the rear tube sheet. The water jacket eliminates the need for a refractory wall

Get A Quote

4 Different Designs of the Fire Tube Boiler: Which Is

3. Scotch Fire Tube Boiler Design. The scotch fire tube boiler design is most commonly referred to as the scotch marine boiler. With this design, the furnace is a big diameter tube located inside of the boiler. The furnace and boiler are circumferenced by water. Some of the larger, older scotch boilers would have two or even three different

Get A Quote

What are fire tube boilers and its application? - Quo

Fire tube boiler: * This is a boiler in which the fire or hot gas is present inside the tubes and water surrounds these fire tubes. * Since fire is inside the tubes and hence it is named as fire tube boiler. The heat from the hot gases is conducte

Get A Quote

Boiler – Fundamentals and Best Practic

2012-7-30 · Boiler - Fundamentals Steam production and steam uses total heat of steam does not vary a great deal as the boiler pressure increase The boiling point (b.p.) increases as the Internal furnace or fire box as the 1st pass Dry back or wet back design Single fuel or dual fuel design

Get A Quote

What is a wetback? When should you use it in

Water circulates through the water jacket, then back to the storage heater. Wetbacks must meet a minimum thermal efficiency of 65%. the hotter the fire burns, the more hot water the wetback will produce. Some systems have thermostats and operate only when the temperature in the source room is above a certain level.

Get A Quote

Wetback Firetube Boilers - Industrial Boiler &

The wet back boiler design uses separate tube sheets between tube passes which can be more forgiving with load changes. Wetback firetube boilers offer a more optimal functional footprint, with lift off or split-hinged doors that require no cool-down period and can be opened immediately.

Get A Quote

Firetube Boilers - National Board of Boiler and

A further subclassification of scotch boilers describes the end closure opposite the burner end of the boiler. A wet-back means the end closure is water cooled and a dry-back means the end closure is not water cooled and relies on fire brick, refractory, or a combination of both …

Get A Quote
Contact us
Tel

0086-510-68530066

Chat online

Online message


Gas-fired(oil-fired) boilers
Coal-fired boilers
Biomass-fired boilers
Thermal oil heaters
Hot water:0.7-14 MW
14.1-21 MW
21.1-29 MW
29.1-75 MW
Steam :  1-10 t/h
11-20 t/h
21-90 t/h
91-140 t/h